RI: 401-438-1500  CA: 213-612-0622  FL: 407-248-1142

English
LaserStar

Optical Repair Laser Welding

Tips for Basic Eyeglass Repair with Laser Welding

Eyeglasses are very rarely composed of noble metals. Therefore, the alloy is a “mystery.” Most “mystery” metals usually melt at a low temperature, low Voltage (V) and low Milliseconds (MS). That is why it is recommended to begin with very low parameter settings and slowly work up on the Voltage (V) and Milliseconds (MS). Due to the metal densities, there are two basic methods used in repairing eyeglasses.

They are as follows:

Method 1 - Direct Welding

Prepping and Setting the LaserStar

Prep the eyeglasses by lightly filing the broken area to a flush fit. Set the LaserStar to achieve a proper keyhole weld.

Tacking

Tack the frames in two or three places to hold the frames together and check alignment.

Run a Bead

Once the frames are straight, run a welding bead by using the 50% overlap technique to run the bead completely around the broken section.

Optical Repair using the LaserStar Welder

Optical Repair Using the LaserStar Welding System

Optical Repair Using the LaserStar

Filling

Use the LaserStar filler wire that is an appropriate match for the color of the plating, i.e. Gold Plate = 10K YG filler, Silver Plate = Silver Solder or 10K WG filler.  Use the same parameter settings that were used for the Keyhole Weld to lie in the filler wire.  If the settings are too strong or too weak, readjust the Voltage (V), Milliseconds (MS) or the Beam Diameter (Ø).

Hammering and Smoothing

Increase the Beam Diameter (Ø) and the Hertz (Hz) to smooth, or hammer the filler material.  Test the frames to see if they will hold up to average pressure.

Optical Repair Using the LaserStar

Optical Repair Using the LaserStar

Method 2 - Capping

Prepping and Setting the LaserStar

Prep the eyeglasses once again by removing any filler material and/or brittle alloy, making sure the joints once again fit flush. Set the LaserStar to achieve a proper keyhole weld. 

Apply filler material to both contact points of the eyeglass frames, making sure there is a small “mound” or “cap” of filler material on each side when finished.

Re-Prep the Eyeglasses

Bring the eyeglasses back to the bench and re-prep them by lightly filing the “mounds” of filler material until the contact points once again fit flush.

Note: Do not remove all of the filler material, just enough to fit the pieces flush.

Optical Repair Using the LaserStar

Optical Repair Using the LaserStar

Optical Repair Using the LaserStar

Welding the Eyeglasses

Once the Keyhole Weld has been established, follow the steps in Method 1. Finished Eyeglass Frame sample below.

Optical Repair Using the LaserStar

Optical Repair Using the LaserStar


×

Developer Tools

Database Activity Performance Tracking Cache Storage Session Storage
2.1661051 seconds
# Seconds Since First Hit Trace Command Type Command Text Parameters Execution Time
1. 0 DBInterface.GetDataT show Text SELECT formID FROM FB_PageKeyMap WHERE PageKey = '/industries/jewelry/case-studies/eye-glass-repair/ show - 0
2. 0 DBInterface.GetDataT show Text SELECT * FROM FB_Input WHERE formID = 0 ORDER BY sequence; - 0
3. 0.0163411 SqlBASE.GetDataTable show Text SELECT TOP(1) HTMLArticles.ID AS ArticleID, HTMLContent.ID, PageTitle, PageMetaDesc, PageMetaKwords, show - 0.0163411
4. 0.1597119 SqlBASE.GetDataTable show Text SELECT TOP(1) HTMLArticles.ID AS ArticleID, HTMLContent.ID, PageTitle, PageMetaDesc, PageMetaKwords, show - 0
5. 0.2226077 SqlBASE.GetDataTable show Text SELECT HTMLContent.PageKey, HTMLContent.PageHeading, HTMLContent.PageContent, HTMLContent.NumLatestA show - 0.0156572
6. 0.2226077 SqlBASE.GetDataTable show Text SELECT TOP(1) ID, Content FROM HTMLMiscContent WHERE SiteID = 1 AND ContentKey = 'Sidebar Quick Link show - 0
7. 0.2226077 SqlBASE.GetDataTable show Text SELECT TOP(1) ID, Content FROM HTMLMiscContent WHERE SiteID = 1 AND ContentKey = 'Sidebar Block 1' - 0
8. 0.2382279 DBInterface.GetDataT show StoredProcedure LanguagePageCheck @PageUrl=/industries/jewelry/case-studies/eye-glass-repair/default.aspx
 0
9. 0.2382279 DBInterface.GetDataT show Text SELECT TOP(1) ID, Content FROM HTMLMiscContent WHERE SiteID = 1 AND ContentKey = 'Header Social Link show - 0
10. 0.2538631 DBInterface.GetDataT show Text SELECT TOP(1) ID, Content FROM HTMLMiscContent WHERE SiteID = 1 AND ContentKey = 'Header Social Link show - 0
11. 0.2694862 DBInterface.GetDataT show Text SELECT TOP(1) ID, Content FROM HTMLMiscContent WHERE SiteID = 1 AND ContentKey = 'Custom Footer Link show - 0
12. 0.2694862 DBInterface.GetDataT show Text SELECT TOP(1) ID, Content FROM HTMLMiscContent WHERE SiteID = 1 AND ContentKey = 'Custom Footer Link show - 0
13. 0.2851111 DBInterface.GetDataT show Text SELECT TOP(1) ID, Content FROM HTMLMiscContent WHERE SiteID = 1 AND ContentKey = 'Custom Footer Link show - 0.0156249
14. 0.2851111 DBInterface.GetDataT show Text SELECT TOP(1) ID, Content FROM HTMLMiscContent WHERE SiteID = 1 AND ContentKey = 'Custom Footer Link show - 0
15. 0.2851111 DBInterface.GetDataT show Text SELECT TOP(1) ID, Content FROM HTMLMiscContent WHERE SiteID = 1 AND ContentKey = 'Custom Footer Link show - 0
16. 0.2851111 DBInterface.GetDataT show Text SELECT TOP(1) ID, Content FROM HTMLMiscContent WHERE SiteID = 1 AND ContentKey = 'Footer Location 1' - 0
17. 0.2851111 DBInterface.GetDataT show Text SELECT TOP(1) ID, Content FROM HTMLMiscContent WHERE SiteID = 1 AND ContentKey = 'Footer Location 2' - 0
18. 0.2851111 DBInterface.GetDataT show Text SELECT TOP(1) ID, Content FROM HTMLMiscContent WHERE SiteID = 1 AND ContentKey = 'Footer Location 3' - 0
19. 0.3007366 DBInterface.GetDataT show Text SELECT TOP(1) ID, Content FROM HTMLMiscContent WHERE SiteID = 1 AND ContentKey = 'Footer Location 4' - 0
20. 0.3007366 DBInterface.GetDataT show Text SELECT TOP(1) ID, Content FROM HTMLMiscContent WHERE SiteID = 1 AND ContentKey = 'Footer Location 5' - 0
21. 0.3007366 DBInterface.GetDataT show Text SELECT ID FROM HTMLMiscContent_Proposed WHERE SiteID = 1 AND ContentKey = 'Footer Location 5' - 0
22. 0.3007366 DBInterface.GetDataT show Text SELECT TOP(1) ID, Content FROM HTMLMiscContent WHERE SiteID = 1 AND ContentKey = 'Footer Location 6' - 0
23. 0.3007366 DBInterface.GetDataT show Text SELECT ID FROM HTMLMiscContent_Proposed WHERE SiteID = 1 AND ContentKey = 'Footer Location 6' - 0
24. 0.3483053 SqlBASE.GetDataTable show Text WITH CatPath (ParentContentID, ContentID, Iteration) AS ( SELECT HTMLContent_XREF.ParentContentID, H show - 0.0475687
25. 0.3483053 SqlBASE.GetDataTable show Text SELECT ID, PageKey, PageTitle, PageHeading, MenuText, IsMenuItem, CASE WHEN ID = 99 THEN 1 WHEN ID show - 0
26. 0.3483053 DBInterface.GetDataT show Text SELECT TOP(1) ID, Content FROM HTMLMiscContent WHERE SiteID = 1 AND ContentKey = 'Header Phone Numbe show - 0
27. 0.3638878 DBInterface.GetDataT show Text SELECT TOP(1) ID, Content FROM HTMLMiscContent WHERE SiteID = 1 AND ContentKey = 'Header Phone Numbe show - 0
28. 0.3638878 DBInterface.GetDataT show Text SELECT TOP(1) ID, Content FROM HTMLMiscContent WHERE SiteID = 1 AND ContentKey = 'Header Phone Numbe show - 0
29. 0.3638878 DBInterface.GetDataT show Text SELECT TOP(1) ID, Content FROM HTMLMiscContent WHERE SiteID = 1 AND ContentKey = 'Header Phone Numbe show - 0
30. 0.3638878 DBInterface.GetDataT show Text SELECT TOP(1) ID, Content FROM HTMLMiscContent WHERE SiteID = 1 AND ContentKey = 'Header Phone Numbe show - 0
31. 0.3798504 DBInterface.GetDataT show Text SELECT TOP(1) ID, Content FROM HTMLMiscContent WHERE SiteID = 1 AND ContentKey = 'Header Phone Numbe show - 0.0159626
32. 0.3798504 SqlBASE.GetDataTable show Text SELECT HTMLHeaderLinks.LinkText, HTMLContent.PageHeading, HTMLContent.PageKey FROM dbo.HTMLHeaderLin show SiteID=1
 0
33. 0.3798504 SqlBASE.GetDataTable show Text SELECT HTMLHeaderLinks.LinkText, HTMLContent.PageHeading, HTMLContent.PageKey FROM dbo.HTMLHeaderLin show SiteID=1
 0
34. 0.3951328 DBInterface.GetDataT show Text SELECT TOP(1) ID, Content FROM HTMLMiscContent WHERE SiteID = 1 AND ContentKey = 'Header - Custom Li show - 0.0152824
35. 0.3951328 DBInterface.GetDataT show Text SELECT TOP(1) ID, Content FROM HTMLMiscContent WHERE SiteID = 1 AND ContentKey = 'Header - Custom Li show - 0
36. 0.4271261 DBInterface.GetDataT show StoredProcedure [dbo].[DefaultSearchAttributeGetByUserID] @g_UserID =5750009f-3eb5-4444-aa07-5721f664a951
 0.0163703
37. 0.4428097 DBInterface.get_oSQL show StoredProcedure [dbo].[VirtualSitePropertiesLoadBySiteID] @SiteID=1
 0
38. 0.4584042 DBInterface.GetDataT show StoredProcedure [dbo].[VideoMenu_Load] - 0
39. 1.3593381 DBInterface.GetDataT show StoredProcedure [dbo].[Menu_Load] SiteID=1
MenuOnly=1
 0.9009339
40. 1.3593381 SqlBASE.GetDataTable show Text SELECT TOP(1) HTMLArticles.ID AS ArticleID, HTMLContent.ID, PageTitle, PageMetaDesc, PageMetaKwords, show - 0
41. 1.4537971 SqlBASE.GetDataTable show Text SELECT TOP(1) HTMLArticles.ID AS ArticleID, HTMLContent.ID, PageTitle, PageMetaDesc, PageMetaKwords, show - 0
42. 2.1504447 DBInterface.GetDataT show StoredProcedure [dbo].[Menu_Load] SiteID=1
MenuOnly=True
StartingID=221
OwnersMenu=False
 0.6497765
Total DB Execution Time 1.6935176
Cache Key Cache Value
__AppStartPage__~/_appstart.vbhtml ~/_appstart.vbhtml
Intelligencia.UrlRewriter.Configuration.RewriterConfiguration, Intelligencia.UrlRewriter, Version=2.0.0.6, Culture=neutral, PublicKeyToken=0573f3650687980d Intelligencia.UrlRewriter.Configuration.RewriterConfiguration
__AppStartPage__~/_appstart.cshtml ~/_appstart.cshtml
VirtualCatalogInfo-laserstardev.braveriversolutions.com
LeftMenu
  • Owners Group Account
  • Laser Products
  • Industries
  • Education & Training
  • About Us
  • LaserStarTV
  • LaserStar Academy
    • HTMLMiscContent_1_'Custom Footer Links','Footer Social Links','Footer Contact Info','Header Phone Number'
    TopMenu
  • Owners Group Account
  • Laser Products
  • Industries
  • Education & Training
  • About Us
  • LaserStarTV
  • LaserStar Academy
    • CategoryMenu
    HTMLMiscContent_1_'Custom Footer Links','Footer Social Links','Footer Contact Info','Header Phone Number','Homepage Promotion'
    VirtualSiteProperties-laserstardev.braveriversolutions.com E_Com_Web_App.BRS.CMS.VirtualSiteProperties
    Session Key Session Value
    UserId 5750009f-3eb5-4444-aa07-5721f664a951
    IsDynamicallyGeneratedUserId True
    AdminLastSitePage /industries/jewelry/case-studies/eye-glass-repair/default.aspx
    AdminLastPage /GetContent.aspx?PageKey=%2findustries%2fjewelry%2fcase-studies%2feye-glass-repair%2fdefault.aspx&unq=5/2/2024 2:50:23 AM
    OrderNumber
    Section Execution Time
    DBInterface.vb 0
    SqlBase.vb 0.1409436
    DeveloperTools.ascx 0
    Load Time:2.1661051s  |  Database Hits: 42